Where is the fuel tank on my boat?

Where is the fuel tank on my boat?

Stern drive and inboard boats are equipped with permanent fuel tanks that are usually located under the deck, and aren’t meant to be removed. On the other hand, portable fuel tanks are…well, they’re portable, so you can take them off of the boat for refueling.

How do you check a boat fuel tank vent?

Find the access to the fuel tank fill and vent fittings on top of the fuel tank. Once you get to these hoses, remove the vent hose which is most commonly a 5/8″ vent hose. With the hose off, blow on the other end and see if air comes out. If air is free-flowing through the hose.

Should outboard gas tank vent open or closed?

All outboard motors have vented gas tanks. Open the vent after you connect the fuel hose and tank to your motor. If you do not open the vent, your motor will experience a vacuum lock. Remove the filler cap from the fuel tank if your motor begins to “gasp” while you are making way in your boat.

How do I drain gas from my inboard boat?

Steps On How To Drain Gas From Your Fuel Tank Effectively

  1. Step 1: Run the boat on the water.
  2. Step 2: Remove the boat on the water.
  3. Step 3: Put on your protective garments.
  4. Step 4: Connect the hose and the fuel transfer pump or primer bulb.
  5. Step 5: Connect the hose to the fuel receptacle.

Where should portable gasoline fuel tanks be filled on a boat?

-All portable fuel tanks must be filled off of the boat. Once filled, store portable fuel tanks onboard in a well-ventilated area away from the engine and electrical equipment.

Why should a boat gas tank never be full?

It’s important to never fill the tank of your boat beyond 90% full. This leaves room for gas to expand and avoids the potential for overflow. Ensure that all air vents and valves to the gas tank are open.

What happens if a fuel tank is not vented?

If these polyethylene tanks do not have a tank vent and are, therefore, not vented properly, they too will collapse. This does not only happen in transfer tank scenarios. There are many applications in which actual bulk storage tanks have collapsed due to the creation of a vacuum in the plumbing system.

Are boat fuel tanks vented?

Fuel tanks on boats are not pressurized like they are in automobiles. Because of this, inboard boat tanks have an air vent to relieve the pressure that builds while filling a tank.

What happens if fuel tank vent is clogged?

If fuel becomes trapped in the line your tank will then build pressure or vacuum until there is enough pressure to purge the vent which will cause gas and/or odor to come from the vent line. If enough pressure builds up damage could be caused to your tank.

Does a fuel tank need a breather?

Your tank has to breathe. In order to breathe, your tank must have a vent somewhere that will relieve both vacuum and pressure. Gasoline expands in volume as it warms up and shrinks in volume as it cools down.

Where is the vent line on a fuel tank?

When installing a vent hose, avoid sags — aka traps — anywhere in the vent line. As I found out the hard way, these allow fuel to puddle, preventing the marine fuel tank vent system from functioning properly. A typical vent line will run sideways across the top of the tank until it reaches the hull side and then angle upward to the vent fitting.

Where are the inspection ports on a diesel tank?

Ports can be installed in either the top or the side of a diesel fuel tank; the former is preferred when access permits. Even if you have to move a fuel tank to access its inspection ports, they’re still worth having. The alternative is having no access to the inside of the tank under any circumstances.

Can a boat fuel tank vent cause problems?

Not only can this boat fuel tank vent cause issues when filling up, but it can also starve the engine of fuel and leave you stranded. This experience taught me one of the most important lessons about venting fuel tanks on boats. Since that time, the subject has grown more complicated with the EPA-mandated evaporative emissions regulations.

What to do if you find water in your gas tank?

Take action quickly when you first locate water in the fuel line or marine gas tank to possibly avoid repair bills altogether. Water sits under the fuel in a separate layer. If you are offshore and discover water in your fuel and your filter bowl is less than a quarter full of water, drain it and change the filter immediately.

Begin typing your search term above and press enter to search. Press ESC to cancel.

Back To Top